共查询到20条相似文献，搜索用时 401 毫秒
1.
This study investigates the flow and caving characteristics of top coal and roof rock, as well as top coal loss pattern in the fully mechanized top coal caving mining of extra thick coal seams. The two dimensional discrete element numerical simulation software program, particle flow code (PFC), is used for the simulation of top coal caving and the inversion analysis. The original locations, distribution, and migration pattern of caved top coal and lost coal were obtained. The analysis shows that in the initial site of caving, the caved bodies are in the form of arc shaped strips in front of the working face. During the caving, caved bodies of different heights move towards the lower rear of the face at different speeds. The lost coal and caved roof rock are originally located at the interface between coal seam and roof, the lost coal is mainly distributed in the goaf on the floor. Behind the support, the caved top coal bodies originally are arc shaped strips, with the highest points located at the midline of the caving opening. The strips are more curved near the goaf than those near the support. During top coal caving, the strips successively cave, with the adjacent outer strip replacing the caved one. The variations of top coal loss and waste rock ratio with time reflect the different phases of top coal caving. In order to improve coal recovery and limit the amount of caved roof rock, the waste rock ratio should be controlled below 10 %. When the waste rock ratio reaches this value, the caving opening should be closed. This paper provides theoretical bases for the improvement of top coal recovery in the fully mechanized top coal caving mining of extra thick coal seams. 相似文献
2.
针对软弱厚煤层综放开采沿空留巷动压显现明显,顶板易出现不均匀切顶下沉等问题。通过现场调研、理论分析和数值模拟,阐明了软弱厚煤层综放开采沿空留巷动压显现特征和变形机制,提出了软弱厚煤层沿煤层顶板布置沿空留巷变形协同支护体系。研究结果表明：综放开采采出厚度大,沿煤层底板留巷时沿空留巷煤层顶板承载能力差,“底板−巷旁支护体−顶板”支护体系载能力不协调,是造成软弱厚煤层沿空留巷产生大变形的主要原因;沿煤层顶板留巷变形协同支护体系的提出提高了沿空留巷帮部、顶底板及巷旁支护体的协同承载能力,可有效地保证软弱厚煤层沿空留巷的围岩稳定。研究成果在古城煤矿的成功应用,证明了该支护体系在软弱厚煤层综放沿空留巷中的可行性。 相似文献
3.
研究开采上限对煤矿开采具有十分重要的意义,它可以最大程度地开采压滞的煤炭资源,缓解当前大部分煤矿采掘接替紧张的局面。以田庄矿N2601工作面为例,根据已有水文地质资料以及邻近矿井资料,分析了开采区充水条件及底部含水层的赋水特性;采用数值模拟方法,根据上覆岩层的塑性应变情况,分析了冒落带与导水裂隙带的高度范围,最后综合数值模拟结果与“三下”开采规程的要求确定了该矿的开采上限。 相似文献
4.
5.
鄂尔多斯盆地准格尔东部煤田石炭?二叠系 6 煤层为巨厚煤层,煤层底板面临奥陶纪灰岩含水层威胁尤为突出,由于采动效应的影响会形成底板采动破坏带,可能会形成新的导水通道引起突水灾害。针对底板采动破坏带测试问题,提出采用动源动接收的孔中瞬变电磁法,在采前和采后工作面底板钻孔中获取岩层电阻率特征数据的方法。首先通过数值模拟对比孔中瞬变电磁法在完整和二层岩层模型中呈现的电阻率差异性,验证该方法对二层岩层模型具有较好分辨率;然后在准格尔煤田酸刺沟煤矿6119巨厚煤层综放工作面进行试验,通过探查底板电性差异层得到底板破坏深度,经过验证结果准确可靠。研究表明:孔中瞬变电磁法探测技术与测试钻孔相结合,通过对比采前与采后结果获取了较为准确底板破坏深度,对类似条件下的工作面破坏深度测试提供了一种新的方法。 相似文献
6.
榆神矿区保水采煤的工程地质背景 总被引：16，自引：1，他引：15
论述了榆神矿区煤层上覆红土、风化带基岩、未风化基岩的工程地质特征,认为红土层具有较好的隔水性能,风化带基岩中粘土矿物的含量增加,隔水性能明显增强。2-2煤层上覆基岩为中硬岩石,而且有较多的软弱岩石夹层,煤层开采的冒裂带发育高度相对较小,影响不到第四系萨拉乌苏组含水层底部,具有较好的保水采煤工程地质条件。 相似文献
7.
断层对顶板稳定性影响相似模拟试验研究 总被引：13，自引：1，他引：12
通过相似模拟试验方法分析了不同倾向高角度正断层, 在采动影响下顶板岩体变形破坏和矿压分布规律。结果表明, 在采动影响下断层“活化”,断层带及其影响范围内的岩体破碎, 表现为周期断裂步距小, 冒落带高, 尤其是断层下盘, 顶板稳定性差; 当工作面开采到离断层面22.5~ 30 m时, 直到断层位置的前方煤体中支承压力增大, 煤体被压碎, 且随着距断层面距离的缩小, 支承压力的峰值位置向工作面前方转移; 通过断层后, 顶板岩体中支承压力减小, 比无断层存在的情况要低。 相似文献
8.
深部强冲击地压易发矿区厚煤层开采解放层卸压效果数值模拟 总被引：1，自引：0，他引：1
为研究深部强冲击厚煤层开采上、下解放层的卸压效果。采用数值模拟方法,分析不开采解放层,开采下解放层,开采上、下解放层条件下,被解放层的应力变化情况及应力变化规律,计算开采下解放层后的合理卸压角,确定解放层平巷位置。模拟结果表明开采上、下解放层后,应力明显减小,但仍存在高应力区,易发生冲击地压,必要条件下应采用其它辅助卸压方式。证明了煤壁前方应力增加区域一般在煤壁前方8～25m。该研究为工作面开采设计提供理论指导,对防治冲击地压具有一定的现实意义。 相似文献
9.
De-zhong Kong Wei Jiang Yi Chen Zheng-yang Song Zhenqian Ma 《Arabian Journal of Geosciences》2017,10(8):185
Low recovery of longwall top coal caving (LTCC) remains one of the most difficult engineering problems in this mining method and impedes its application. The top coal left in the gob at face end accounts for a large portion of the total coal loss, and the instability of the leftover triangle coal at face end has long been a threat to the safety of miners and the mining equipment. In this paper, based on the engineering background of Ruilong mine, we explore the stability of the roof at the end of the face by using theoretical analysis, numerical simulation, and field measurement. Results reveal that in the inclined longwall top coal caving face, the immediate roof forms an “arch” structure, and the basic roof forms a “masonry beam” structure after the roof collapses; working resistance of the support calculated by the method of ultimate bearing capacity was adequate to meet the requirement of roof load; roof load of coal pillar was related to the length of key block and fracture position; and increasing the size of coal pillar could ensure the stability of both coal pillar and roof. 相似文献
10.
11.
导水裂隙带发育高度是矿井水害预测的重要技术参数之一。以彬长矿区文家坡煤矿4103工作面为研究对象,利用井-地联合微震监测技术对顶板导水裂隙带发育特征进行研究。研究结果表明:深埋煤层开采时,微震事件超前工作面回采位置发育,超前影响角最大为35°,最小为28°;断层的存在降低了覆岩稳定性,相较于正常基岩,更易在回采影响下发生应力集中和破坏;断层加大了微震事件发生的超前距,而采空区则使微震事件的高密度区向其所在部位发生偏移,加剧覆岩破坏程度,增大导水裂隙带发育高度;垂向上,4103工作面监测区内的微震事件高密度区域主要集中在高程+400~+520 m,结合微震事件数量和能量分布特征,判定4103工作面垮落带发育高度为50 m,垮采比13.16,导水裂隙带发育高度为117 m,裂采比为30.79。该成果可为彬长矿区类似煤矿深埋煤层顶板导水裂隙带发育高度研究及顶板水防治提供重要依据。移动阅读 相似文献
12.
浅埋煤层非坚硬顶板强制放顶实验研究 总被引：5，自引：0，他引：5
以南梁煤矿地质资料为依据,通过对不同覆岩条件和不同强制放顶方案的相似材料模拟实验,证明整体性较好的顶板以强制放顶减小工作面初次来压步距是可行的,既可实现工作面连续推进,又可避免顶板大面积垮落带来的安全隐患。实验揭示了地表厚粘土层浅埋煤层单体支柱工作面开采时,顶板活动及矿山压力显现规律;为南梁煤矿单体支柱长壁工作面实现连续开采,提供了可靠依据。 相似文献
13.
Monitoring of strata control parameters and behaviour of a powered support was carried out during an experimental trial of a mechanized longwall sublevel caving face for exploitation of a 7.5m thick coal seam. Field observations indicated that the requirement of support density for underwinning of top coal by sublevel caving under intact strata is different from that for underwinning under broken and fractured rock mass. Analysis of the leg closure observations and support resistance variations during different mining cycles showed rapid increase of the setting load density of the support in relation to the yield load density. This resulted in a large amount of leg closure during mining cycles of the sub level caving face under broken rock strata. Due to operational constraints, the field observations could not provide enough information to visualize the behaviour of the overlying rock strata. Simulation of the field conditions was therefore performed on a physical model to bridge this gap of information. Results of laboratory investigations on the physical model are combined with those of the field to explain the critical behaviour of the support system during sublevel caving under broken rock strata. 相似文献
14.
榆神矿区首采煤层及上覆岩层工程地质特征 总被引：1，自引：1，他引：0
榆神矿区是陕北大型煤炭基地的重要组成部分,区内煤炭资源丰富。近年来,该矿区煤炭开发与生态环境、地质环境的矛盾日益突出。通过分析榆神矿区首采煤层分布、厚度、埋深及其上覆岩层的厚度和顶面形态,根据岩石成因、工程地质特征及物理力学性质,将该区岩(土)体划分为4个类型和7个岩组: 松散岩类(沙层组、土层组)、软岩类(风化岩组、煤岩组、烧变岩组)、较软岩类(粉砂岩与泥岩互层岩组)和较坚硬岩类(砂岩组),总结了各岩组的分布、厚度和物理力学特征。结果表明: 矿区煤层顶板多为中等—难冒落型顶板,局部地段属易冒落型顶板; 粉砂岩及细粒砂岩底板属稳定型底板,泥岩底板稳定性差。为指导矿区规划、环境评估及煤炭开发提供依据,对切实转变陕西煤炭发展方式、促进生态环境友好型矿山的发展具有积极意义。 相似文献
15.
煤层底板变形破坏除受地质因素控制外,还受开采因素影响。通过试验和理论分析,系统研究了煤炭开采对回采工作面底板应力、应变和破坏及渗透性的影响。研究结果表明,不同岩性岩石的渗透性在全应力-应变过程中为应变的函数,在微裂隙闭合和弹性变形阶段,岩石的原生孔隙和裂隙容易被压密,岩石的渗透率随应力的增加由大变小明显,当应力增大至极限强度时岩石试件破坏形成贯穿裂隙,岩石的渗透率迅速增大至最大,不同岩性岩石存在一定差异性;随着回采工作面推进,煤层底板岩层在横向上划分为原岩应力区、超前压力压缩区、采动矿压直接破坏区和底板岩体应力恢复区4个区。煤层底板岩体的渗透性随着煤炭开采底板岩体变形破坏而呈规律性变化。 相似文献
16.
In order to master the tendency mining-fracture-evolution characteristics of overlying strata and coal seams above working face with large inclination angle and mining depth in mining process, the 1221 working face in Zhao mine is selected as the engineering background and a mathematical model is established. The displacement variation, stress and strain of overlying strata and coal seams are simulated by using ANSYS software. In the mining process, the movement characteristics, displacement variation laws and fracture evolution characteristics of overlying strata and coal seams above working face with large inclination angle and mining depth along inclination direction are discussed. Simulation results show that with the advance of working face, the fracture development of overlying strata and coal seams is larger and larger; the area of gob is gradually expanding and the transverse stress of overlying strata and coal seams is also expanding. Stress contour of overlying strata and coal seams at both ends of gob becomes denser and denser; the activity of the overlying strata and coal seams near the up-roadway side of the gob is violent. The pressure relief zone is formed in the upper part of the strata and the roof above the gob. Large inclination angle of coal seam results in larger supporting pressure in the underside of the gob and smaller supporting pressure in the upper side of the gob. Along the inclination direction of the working face, the pressure relief zone is mainly concentrated in the outlet roadway of the working face; the fracture development and strata separation are obvious, which offer good passage for gas flow and migration. 相似文献
17.
应用覆岩空间结构学术观点对孤岛顶煤综放采场冲击矿压机制及其控制技术进行研究。根据覆岩关键层的岩性、层位、范围等因素,覆岩关键层空间结构分为覆岩空间大结构和基本顶有限矿压结构。孤岛顶煤采场冲击矿压发生机制：①孤岛顶煤综放采场 ? 型空间大结构形成过程是集中压力逐渐增加的过程,是该时间段发生冲击矿压的力源;②采场基本顶形成最下位 ? 型空间结构后,随着工作面推进,基本顶块体产生滑落失稳,造成工作面冲击矿压现象。通过对分段来压理论、基本顶结构失稳理论和坚硬顶板预断裂理论对覆岩关键层空间结构运动的控制作用研究,提出采用覆岩空间结构理论分析、分阶段降低放煤率、坚硬覆岩预爆泄压技术、覆岩坚硬岩层破裂的微地震监测技术等方式方法预防冲击矿压的发生。 相似文献
18.
多煤层开采条件下煤层覆岩破坏具有独特的特征，影响矿井生产布置。以陕北某矿为例，以该矿地质采矿条件为基础，采用相似材料模拟实验与数值模拟相结合的方法，通过建立模拟模型，开展了双煤层开采对覆岩的破坏影响研究。结果显示:留设不同宽度的煤柱，采用相似材料模拟和数值模拟2种方法得到的煤层覆岩垮落带高度、裂隙带高度都基本一致；在双煤层开采时，留设的煤柱宽度越大，两个煤层的叠置区域就越小，煤层开采对覆岩的破坏程度就越小。在工作面布置时，建议增大两个煤层的开采距离，并尽量增加煤柱宽度，以减缓覆岩移动破坏范围和破坏程度。研究成果为类似双煤层开采工作面的设计及覆岩破坏控制提供技术支撑。 相似文献
19.
为研究开采上保护层对巨厚砾岩断裂诱发冲击的防治作用,根据跃进煤矿25采区的地质条件和采掘条件,将25110工作面下巷作为研究对象,从理论上分析了动静载叠加诱发冲击矿压的机制以及开采上保护层后的防冲原理,数值模拟研究了未开采上保护时和开采上保护层后在同等强度的动载扰动应力的影响下巷道底板的位移、速度、应力以及塑性区的变化规律,进行相似模拟试验研究了人工震源的作用下未开采上保护时和开采上保护层后巷道底板的加速度和动应力响应规律。结果表明,上保护层开采后能够有效地释放围岩内部的高应力,且采空区顶板自然垮落,形成的软弱松散岩层结构,能够更好地起到对动载扰动应力波的衰减作用,从而降低了冲击矿压发生的可能,一定程度上能够较好地防治冲击矿压。研究成果对巨厚砾岩下冲击矿压的防治具有一定指导意义。 相似文献
20.
浅埋煤层过沟开采在陕北矿区普遍存在,严重威胁着矿井安全生产和生态健康发展。覆岩采动裂隙及地表裂缝的发育是岩体微裂隙的延伸和扩展的结果,为更加系统地研究浅埋煤层过沟开采覆岩微裂隙的演化规律,以陕北安山井田125203工作面为背景,根据现场沟道剖面及钻孔资料,采用Particle Flow Code (PFC)数值模拟平台构建颗粒流数值采煤模型,模拟分析覆岩微裂隙的发育特征、数量变化规律和力链演化特征,揭示微裂隙的发育规律和地表裂缝发育机理。结果表明:浅埋煤层过沟开采过程中,覆岩微裂隙发育表现为“产生–延伸和扩展–聚合成群–贯通成缝”的动态演化过程;根据微裂隙的基本发育特征及分布规律,可将发育全程划分为非连续跳跃式、连续贯通式和横向扩展式3个微裂隙发育阶段;覆岩微裂隙数量随工作面推进距离的增大而增多,非连续跳跃式和连续贯通式发育阶段呈现指数增长特征,分别累计发育微裂隙547和2 867条,覆岩微裂隙逐渐发育至地表;横向扩展式发育阶段呈线性增长特征,累计发育微裂隙11 705条,微裂隙数量随岩层高度的增大而减小;覆岩力链演化过程中,强黏性力链的破坏致使微裂隙发育,局部产生应力集中,强黏性力链拱自下而上逐渐破坏并贯通至地表,导致微裂隙延伸发育至地表形成地裂缝,力链在未贯通岩层的微裂隙两侧和尖端及地表裂缝两侧形成强力链区,微裂隙处形成弱(无)力链区。该研究成果可为陕北矿区浅埋煤层过沟开采覆岩及地表损害防控提供理论指导。 相似文献