共查询到19条相似文献，搜索用时 125 毫秒
1.
应用氯化镁—石灰乳法制备高纯氧化镁,降低氧化镁中钙含量是保证氧化镁产品质量的关键。通过对氧化镁的常温水化及二次煅烧,有效降低了氧化镁中钙含量,并通过正交试验得到了最优的水化工艺参数。氢氧化镁经850℃煅烧120 min,然后水洗,再次在1 050℃煅烧120 min,所得氧化镁纯度为99.1%99.4%,水化后钙含量(以CaO计)降低了约1%。 相似文献
2.
以硫酸镁和氨气为原料,直接制备高浓度阻燃剂氢氧化镁。通过单因素实验确定了最佳工艺条件,搅拌强度450r／rain,氨镁摩尔比2．4：1,氨气加入流量500mL／min,陈化时间60min,反应温度60℃,硫酸镁浓度2．50mol／L。用扫描电镜、X射线衍射仪和激光粒度仪表征产品的形貌、结构及粒度。在最佳工艺条件下得到,D5012．06μm,D90 18．99μm,料浆浓度7．37％,Mg收率68．02％,氢氧化镁纯度96．75％。 相似文献
3.
4.
5.
6.
7.
纳米及微米级六角片状氢氧化镁的制备 总被引：2，自引：2，他引：0
以氯化钠为底料,水氯镁石和氢氧化钠为原料,不添加任何添加剂,采用双柱沉淀—水热法制备粒度分布均匀、分散性良好的氢氧化镁。研究了进料速度、2N_(Mg)/N_(Na)、物料浓度、水热温度、水热时间等因素对氢氧化镁粒径、形貌、过滤性能的影响。通过粒度分析仪、X射线衍射仪、低真空扫描电子显微镜对产品的粒度分布、结构和形貌进行了表征。结果表明,本研究得到的样品分散性好,粒度分布均匀,形貌为规则的六角片状,粒径为400~600 nm的纳米级氢氧化镁或者1~2μm的微米级氢氧化镁。 相似文献
8.
9.
以活性氧化镁和氯化镁为原料在水热条件下合成了碱式氯化镁晶须。碱式氯化镁晶须热解后形貌保持得很好,得到氧化镁晶须。制得的晶须长度在200μm左右,直径约0.5μm。采用X射线衍射仪、扫描电镜、热重分析仪表征碱式氯化镁和氧化镁晶须,探讨了各个工艺条件对产物的影响。实验结果表明,碱式氯化镁晶须的最佳工艺条件为:反应时间8~12 h,搅拌速率初始在500 r.min-1左右,120 min时调为1 000 r.min-1,氧化镁与氯化镁的物质的量之比0.10~0.15,氯化镁溶液的浓度4.0 mol.L-1以上,反应温度150~200℃,反应釜的填充度50%~80%。在此条件下制得了形貌良好的碱式氯化镁晶须。 相似文献
10.
以盐湖副产水氯镁石为原料,与一定比例的石灰反应得到氢氧化镁和氢氧化钙的混合沉淀物,该混合物经过滤、洗涤、烘干后在一定温度下煅烧得到符合皮江法炼镁用的合成煅白。实验结果表明,该工艺是可行的,在石灰/氯化镁摩尔比2.05~2.10∶1,反应时间1.0h,煅烧温度800℃,煅烧时间60 min时,合成的煅白中钙镁摩尔比0.95~1.07∶1,煅白的平均水活度达34%,符合硅热法炼镁用中间原料煅白的参数条件。该技术可为利用盐湖氯化镁制备金属镁新工艺开发提供数据参考。 相似文献
11.
以硫酸镁和氢氧化钠为原料,通过水热法合成了碱式硫酸镁晶须5Mg(OH)2.MgSO4.2H2O(简称512MOS)。考察了前驱体制备方法、反应时间、反应温度以及形貌控制剂EDTA对碱式硫酸镁晶须形貌的影响,得出了较佳合成条件。研究结果表明,以固体氢氧化钠制备前驱体,在较低的温度下进行水热反应,可以获得形貌较好的晶须。添加EDTA可以改善晶须形貌,减少扇形晶须的出现。在较佳条件下制备的碱式硫酸镁晶须平均长度约40μm,平均直径约0.4μm,长径比达到100左右。XRD和化学分析显示产物组成为512MOS。SEM照片显示产物形貌为单根纤维状,表面光滑,有柔性弯曲现象。 相似文献
12.
氯氧镁水泥(Magnesium oxychloride cement, MOC)具有快凝、早强、高强、防火和不腐蚀玻璃纤维等优点,非常适合于制作玻璃纤维增强薄壁制品,在农业灌溉工程中具有良好的应用前景。采用XRD和TOPAS分析了新型抗水氯氧镁水泥制成内蒙古防渗渠的物相组成,探讨了氯氧镁水泥制品在自然环境的水化产物与相转变规律、以及相组成对强度的影响。结果表明,在水分缺少的条件下,氯氧镁水泥的水化产物主要为5Mg(OH)_2·MgCl_2·8H_2O(5·1·8)和Mg(OH)_2;在水分充足的条件下,水化产物主要为Mg(OH)_2和5·1·8,碳化产物为碳化氯氧化镁Mg(OH)_2·MgCl_2·2MgCO_3·6H_2O(1·1·2·6)和水菱镁矿4MgCO_3·Mg(OH)_2·4H_2O(4·1·4)。水化产物对强度有促进作用,而碳化产物会降低强度。通过10年的工程环境考验,证明新型氯氧镁水泥制品在环境中能够保持主要强度相5·1·8的稳定性,具有良好的长期力学性能。 相似文献
13.
14.
The crystal structure of metal borates has been extensively investigated by X-ray and neutron diffraction,but,the structure of aqueous polyborate solutions are still largely unknown.Over the last decade,our group has focused on studying the structure of complex aqueous polyborate solutions of Li,Na,K,Rb,Cs,and Mg using synchrotron radiation X-ray scattering(XRS),EXAFS,Raman,NMR,and DFT,as well as determining the density,conductivity and pH of such solutions.Polyborate species distributions were calculated using pH measurements,and the main species in the solution have been confirmed by NMR and Raman spectra.For alkali-metal metaborates,the dominant species is always B(OH)-4in a wide range of concentration,while the presence of others species is negligible.For alkali metal tetraborates,when concentration is in the extreme low range,only B(OH)3 and B(OH)-4 are present in these solutions.As the total boron concentration increases,B(OH)3 and B(OH)-4 polycondensated to form more complex oligomers.Of them,while B4O5(OH)2-4 in the tetraborate solutions is the main species,B(OH)3,B(OH)-4,and B3O3(OH)-4 are minor species,and B3O3(OH)2-5 and B5O6OH)-4 are present only in negligible amounts.As solution continues to concentrate,B4O5(OH)2-4 eventually becomes the dominant species,which is consistent with the congruent compound M2B4O7·nH2O(M=Li,Na,K,Rb,Cs) in the system M2O-B2O3-H2O(M=Li,Na,K,Rb,Cs).For alkali metal pentaborates,B(OH)3 and B(OH)-4 are the main species at low concentrations.The species distribution,Raman and NMR spectroscopy results verified that the dominant species in concentrated pentaborate solutions with Li and Na is pentaborate B5O6OH)-4,but it is surprising that the main species with K,Rb,and Cs is always the triborate monoanion B3O3(OH)-4.Although all M[B5O6OH)4]·nH2O(M=Li,Na,K,Rb,Cs) are all congruent compounds in the system M2O-B2O3-H2O(M=Li,Na,K,Rb,Cs) ,the main species in aqueous solutions are quite different because of various cation hydration distance(d),hydration number(CN),and configuration,especially charge(Z).For bivalent Mg2+,three borate minerals,namely,Inderite(2MgO·3B2O3·15H2O),Hungchaoite(MgO·2B2O3·9H2O),and Mcallisterite(MgO·3B2O3·7.5H2O),exist in the system MgO-B2O3-H2O at 298K.Inderite is a congruent compound,but Hungchaoite and Mcallisterite are incongruent compounds.The species distribution and Raman spectra demonstrat that the predominant species in all the solutions with magnesium borates is bivalent triborate B3O3(OH)2-5,while the subordinate species are B(OH)-4 at a low B2O3/MgO ratio and B(OH)3at a high B2O3/MgO ratio,and the other anions are negligible,as the high Z of the borate anion must match that of Mg2+.The disappearance of divalent B4O5(OH)2-4 is in agreement with its incongruent nature.The DFT and XRS results showed that tetrahedral Li(H2O)+4(d=0.20 nm,CN=4),octahedral Na(H2O)6+(d=0.236 nm,CN=6),and Mg(H2O)2+6(d=0.210 nm,CN=6) in the first hydration shell belong to Platonic polyhedra.However,K(H2O)+8(d=0.28 nm,CN=8,XRS and DFT),Rb(H2O)+8(d=0.293 nm,CN=7.7-8.2,EXAFS),and Cs(H2O)+8(d=0.320-0.326 nm,CN=7.6-7.9,EXAFS) are inclined Voronoi polyhedra.Therefore,the effects of cation Z and d on the structure of polyborates in aqueous solutions are deterministic,while the effect of hydrated-cation symmetry is secondary.Their hydrolysis order was:Mg＞Li＞Na＞K＞Rb＞Cs,in step with hydration power.Among them,Mg2+ and Li+have a strong tendency towards hydrolysis,but Na+ scarcely hydrolyzes,especially Rb+ and Cs+ have a little protonation.X-ray scattering of aqueous alkaline sodium borohydride solutions confirmed that dihydrogen bonds exist in an aqueous solution.The four distinct features of dihydrogen bonds in aqueous solution-unidirectionality,divaricativity,multicentricity,and multidentativity have been also described here in brief. 相似文献
15.
16.
17.
18.
干密度是评价软土固化质量的重要指标,一般通过室内击实试验获得。以氯氧镁水泥(MOC)为结合料,砾石土为固化对象,研究了原料配比对MOC固化砾石土击实性能的影响。通过室内击实试验,考察了轻烧镁粉掺量、卤水浓度、卤水掺量和活性MgO/MgCl_2物质的量比(Mg/Cl比)影响混合料干密度的规律。结果表明:MOC固化砾石土击实料的干密度随卤水掺量增加先增加后降低,随轻烧镁粉掺量及Mg/Cl比的增加而先增加后降低,随卤水浓度及轻烧镁粉掺量的增加而增加,随卤水浓度增加及Mg/Cl比降低而增加。 相似文献
19.
在槽式太阳能热发电领域,硝酸镁基熔盐逐渐引起关注。通过六水硝酸镁煅烧法制备无水硝酸镁,采用拉曼、DSC与XRD表征脱水产物,系统研究了环境压力、脱水温度与时间对六水硝酸镁脱水和水解的影响。结果表明,六水硝酸镁在煅烧过程中水解为碱式硝酸镁Mg_3(OH)_4(NO_3)_2,在水溶液中进一步分解为Mg(OH)_2。随着煅烧温度和时间的增加,脱水产物中的含水量逐渐减少,同时水解产物Mg_3(OH)_4(NO_3)_2含量逐渐增加。真空环境下煅烧,可显著降低硝酸镁的水解反应。六水硝酸镁在真空环境下230℃煅烧1.5 h,所制备的无水硝酸镁中水解产物含量为3.63%。制备的硝酸镁可进一步用于硝酸镁基熔盐的研究。 相似文献