基于可靠性的海洋立管疲劳安全系数研究     

吴剑国  万子诚  李智博  张萌  戴伟  孙政策 《海洋工程》2018,36(6):1-9

综合考虑了立管疲劳安全系数取值的相关因素——立管的安全等级、设计寿命、检验周期、载荷和损伤计算方法等的不确定性,提出了基于可靠度的疲劳安全系数确定方法,筛选了用于计算波致疲劳和VIV(涡激振动)疲劳的随机变量,给出了立管波致疲劳与VIV疲劳安全系数的计算流程,并以某SCR(钢悬链线立管)为例进行了安全系数计算。结果表明,该方法的计算结果优于传统的安全系数确定方法,尤其适合于特殊工程方案或新颖设计的立管疲劳校核。  相似文献   

深水铺管船托管架疲劳分析及动态监测点选取研究     

闫宏生  王哲  王晓波  陈永訢  孟祥伟 《海洋工程》2018,36(1):107-113

作为S型铺管作业的关键性装备,托管架长期承受着交变载荷的作用,随着海洋开发向超深水发展,结构疲劳破坏问题不容忽视。采用疲劳谱分析的方法并结合线性累积损伤理论,对托管架结构频域下的变形进行了分析,计算了正常海况下和极端海况下托管架疲劳损伤度并对疲劳寿命进行了评估。研究发现托管架在正常海况下作业符合安全要求,在极端海况下局部结构会受到破坏。并从托管架结构安全监测角度,筛选了结构疲劳分析关键点位,为监测点位的选取提供了依据。  相似文献   

Analysis of Safe Span Length and Fatigue Life of Submarine Pipelines     

HE Zhang-feng  WEI Yuan  LIU Shu-lin 《中国海洋工程》2020,(1):119-130

Owing to the complex environmental conditions, suspension could induce complicated forces on submarine pipelines and even cause vortex-induced vibration, resulting in fatigue damage of pipelines. Through aiming at the 28-inch submarine pipeline in the East China Sea, the pipeline was segmented according to the similarity, considering the factors of pipe assembly, typhoon, current, wave and seabed topography. The effects of span length on natural frequency in each section of submarine pipeline were analyzed by finite element model. The maximum safe span length allowed by each pipeline section was verified by fatigue cumulative damage theory, and the fatigue life of each pipeline section were predicted. The results showed that each order natural frequency of the pipeline decreased with the increase of span length. The calculated results of empirical formulas were much smaller than those of the FEM analysis. The increase of the gap between the suspended pipeline and the seabed was beneficial to enhance the fatigue life of the suspended pipeline.  相似文献   

基于并行计算的海洋平台谱分析疲劳筛选技术研究     

李洛东  刘成名  梁园华 《海洋工程》2018,36(5):56-64

为了得到海洋平台疲劳失效风险最大的焊接区域,提出了以有限元网格单元应力为基础的谱分析筛选方法,并开发了程序。程序采用并行计算架构,单次完成数万个单元的累积损伤度/疲劳寿命计算,并通过有限元软件以云图方式显示疲劳寿命。采用该程序计算双浮筒半潜式平台的疲劳寿命。结果表明,该型平台疲劳失效风险较高的区域为立柱与上壳体下浮体连接对角线转角区域、浮筒中纵舱壁与立柱连接区域。并行计算方法的引入,大大缩减疲劳损伤度计算的分析时间,采用22核心的CPU,时间缩短为原来的1/18.5,17小时完成全平台外壳单元谱分析计算。  相似文献   

周期荷载下盐岩的疲劳变形及损伤特性研究   总被引：7，自引：0，他引：7  

郭印同  赵克烈  孙冠华  杨春和  马洪岭  张桂民 《岩土力学》2011,32(5):1353-1359

利用RMT-150C型岩石力学多功能试验机,进行了盐岩单轴循环荷载作用下的疲劳试验,研究了盐岩的疲劳强度、变形及损伤特性。试验结果表明,当上限应力大于"门槛值"时,盐岩疲劳破坏时的轴向应变可以分为初始变形、等速变形和加速变形3个阶段,呈疏-密-疏的发展过程。改变上限应力和平均应力会显著影响疲劳的进程,提高上限应力值和平均应力值,初始轴向变形和循环轴向变形的比率都会提高,疲劳破坏时的总循环次数显著减小。盐岩疲劳破坏终点的变形量同样受静态轴向应力-应变全过程曲线的控制,控制误差范围在10%左右。循环荷载作用下,盐岩的变形模量经历了一个先逐渐增加,后缓慢降低,最后加速减小的过程。对循环荷载作用下盐岩疲劳损伤演化规律进行了初步探讨。  相似文献   

近岸波生流运动三维数值模拟及验证   总被引：3，自引：0，他引：3       下载免费PDF全文

解鸣晓  张玮 《水科学进展》2011,22(3):391-399

开发建立了近岸波生流运动三维数值计算模式。模式中,引入了三维时均剩余动量、破波表面水滚、波浪水平与垂向紊动作为主要驱动力,同时考虑了波流共同作用的底部剪切力。推导了可综合反映底坡、能量传递率和密度影响的水滚能量传输方程;将Larson-Kraus的二维波浪水平紊动系数表达式拓展至三维。采用大量实测数据和文献资料测试验证了所建模式,表明所建模式可有效模拟波浪增减水、底部离岸流、沿岸流、裂流、堤后环流等不同维度的波生流现象。此外,研究也表明破波水滚效应可解释波生流峰值向岸推移的物理现象,从而在模拟中不能忽略;破波带内沿岸流速垂向较为均匀的现象与波浪附加垂向紊动有关。  相似文献   

Numerical simulation of wave-induced currents combined with parabolic mild-slope equation in curvilinear coordinates     

崔雷  佟飞飞  石峰 《中国海洋工程》2011,25(3):457-468

Researches on breaking-induced currents by waves are summarized firstly in this paper. Then, a combined numerical model in orthogonal curvilinear coordinates is presented to simulate wave-induced current in areas with curved boundary or irregular coastline. The proposed wave-induced current model includes a nearshore current module established through orthogonal curvilinear transformation form of shallow water equations and a wave module based on the curvilinear parabolic approximation wave equation. The wave module actually serves as the driving force to provide the current module with required radiation stresses. The Crank-Nicolson finite difference scheme and the alternating directions implicit method are used to solve the wave and current module, respectively. The established surf zone currents model is validated by two numerical experiments about longshore currents and rip currents in basins with rip channel and breakwater. The numerical results are compared with the measured data and published numerical results.  相似文献   

自由站立式立管总体运动疲劳分析     

康庄  李辉  孙丽萍  冯玮  贾旭 《海洋工程》2011,29(4):43-50

由于良好的疲劳特性,自由站立式立管(FSHR)正广泛应用于深海油气田的开发当中。首先根据设计参数建立FSHR详细的有限元模型,然后利用谱分析方法对FSHR进行总体运动疲劳分析,以确定FSHR总体设计参数是否满足运动疲劳要求。最后对工作于相同环境下的钢悬链立管(SCR)进行总体运动疲劳分析,探讨哪种立管系统的疲劳性能更为优良。计算结果表明FSHR系统中刚性主管最大运动疲劳损伤出现在刚性主管顶部,FSHR总体设计参数满足规范要求;FSHR总体运动疲劳寿命要远大于SCR,体现了FSHR系统对浮体运动与刚性主管之间具有良好的解耦作用。  相似文献   

冰激直立腿海洋平台疲劳寿命分析   总被引：1，自引：1，他引：0  

张大勇  刘笛  许宁  岳前进  郭龙玮 《海洋工程》2015,33(4):35-44

由于渤海特殊环境条件与油藏分布决定了该海域导管架油气平台属于典型的柔性抗冰结构。多年现场观测发现,该类结构存在显著的冰激振动现象。冰振不仅能激起较大的甲板加速度响应,还会引起明显的导管架管节点交变应力。在结构设计与安全保障中进行疲劳分析及寿命估计是必要的。对于直立腿抗冰结构,精确的冰激疲劳寿命计算方法还不成熟。基于多年的现场监测,首先分析了冰与直立腿抗冰结构相互作用过程;其次,提出了冰激直立腿平台的疲劳寿命分析流程;最后,选取渤海某典型直立腿平台,利用ANSYS数值模拟,对比了稳态冰力和随机冰力下结构的疲劳损伤,进而计算出疲劳寿命。本研究为寒区柔性结构抗冰设计与安全保障提供了理论基础。  相似文献   

Experimental Study on Response Performance of VIV of A Flexible Riser with Helical Strakes   总被引：1，自引：1，他引：0  

高云  付世晓  曹静  陈一帆 《海洋工程》2015,29(5):673-690

Laboratory tests were conducted on a flexible riser with and without helical strakes. The aim of the present work is to further understand the response performance of the vortex induced vibration (VIV) for a riser with helical strakes. The experiment was accomplished in the towing tank and the relative current was simulated by towing a flexible riser in one direction. Based on the modal analysis method, the displacement responses can be obtained by the measured strain. The strakes with different heights are analyzed here, and the response parameters like strain response and displacement response are studied. The experimental results show that the in-line (IL) response is as important as the cross-flow (CF) response, however, many industrial analysis methods usually ignore the IL response due to VIV. The results also indicate that the response characteristics of a bare riser can be quite distinct from that of a riser with helical strakes, and the response performance depends on the geometry on the helical strakes closely. The fatigue damage is further discussed and the results show that the fatigue damage in the CF direction is of the same order as that in the IL direction for the bare riser. However, for the riser with helical strakes, the fatigue damage in the CF direction is much smaller than that in the IL direction.  相似文献