共查询到20条相似文献，搜索用时 31 毫秒
1.
Seyed Esmaeil Mousavi 《Geotechnical and Geological Engineering》2018,36(1):77-87
Silica fume is identified as a pozzolan and supplementary cementitious material that can utilize to improve the mechanical properties of stabilized soil with cement. Silica fume wherein mixes with cemented soil in a proper dosage, it is susceptible to induce pozzolanic effect in cemented soil due to its fineness and high content of SiO2 and Al2O3. The pozzolanic effect is vital to ensure ongoing strength of stabilized soil with cement. Up to now, stabilization of clay with cement and silica fume is not completely explored. This paper investigates: (i) the capability of utilizing the silica fume as a supplementary material for cement to maximize the filler and pozzolanic effects of compacted and stabilized soil (ii) the mechanical properties of compacted and stabilized clay with various proportions of cement and silica fume. For this purpose, a total of 120 untreated and stabilized soil admixtures were prepared by replacing ordinary Portland cement with silica fume. The influence of partial replacement of cement with silica fume on the bearing capacity, shear and compressive strength of compacted and stabilized soil was investigated. To achieve such aims, the stabilized soil specimens were examined in laboratory under direct shear, unconfined compression and California bearing ratio tests. Based on the findings of this paper the 28-day UCS of the stabilized soil with 2% partial substitution of cement with silica fume is almost 3.5-fold greater than that of the untreated. It was found that the optimum mix design for the stabilized soil is 6% cement and 2% silica fume. In conclusion, a notable discovery is that the partial substitution of cement with 2% silica fume in the optimum mix design significantly refined the pore spaces as a result of pozzolanic activity and filler effect of silica fume. 相似文献
2.
湖泊底泥改性固化的强度特性和微观结构 总被引：1，自引：0，他引：1
将灰渣胶凝材料作为改性剂应用于湖泊环境疏浚底泥的固化处理,研究了改性淤泥的强度特性,探讨灰渣胶凝材料对淤泥的改性机理。改性淤泥的抗压强度试验结果表明,当灰渣胶凝材料质量掺入比为5 %时,能够显著提高改性淤泥的各个龄期强度;当掺入质量比为12.5 %时,28天强度可以达到1.55 MPa。改性淤泥的早期强度较高,后期强度能持续增长,同时具有良好的耐水浸泡性能。SEM分析表明,灰渣胶凝材料能与底泥颗粒中的活性物质发生火山灰反应,形成高强难溶的胶结物,使改性淤泥中大孔隙数量减少,改善了淤泥土颗粒之间的胶结性能。这说明灰渣胶凝材料是一种性能优异的底泥改性材料。 相似文献
3.
矿渣磷酸镁水泥的力学性能和水化机理 总被引：1，自引：0，他引：1
以高炉矿渣作为磷酸镁水泥(MPC)的活性混合材料,研究了MPC的凝固时间、力学性能、物相组成和显微结构,并探讨了矿渣MPC的作用机理。实验固定磷镁比为25%,硼镁比为7.5%,矿渣掺量分别为磷镁总质量的0%、10%、20%、30%和40%。结果表明,矿渣参与了水化反应并提高了MPC的胶凝性能,随着矿渣掺量增大,矿渣MPC的抗压强度提高,但矿渣水化产生的膨胀应力会破坏MPC的内部结构,因此其抗折强度随矿渣掺量增大而降低。矿渣MPC的主要水化产物为六水合磷酸镁铵(MgNH4PO4.6H2O),矿渣的掺入使凝胶相增加,并有部分Ca2+进入MgNH4PO4.6H2O晶格,使水化产物的形貌、大小发生变化。样品中剩余较多死烧镁和矿渣颗粒,可起骨料作用。 相似文献
4.
Noor-ul-Amin 《中国地球化学学报》2010,29(2):143-145
In this investigation local clay from Cherat mines, Nowshera District, NWFP, Pakistan, has been tested as a pozzolanic material in high strength Portland cement. Thermal treatments were performed as a means of activation of the clay. It was found that thermal treatment of the clay can increase its pozzolanic activity. Different blended mortars, containing different amounts of clay, activated at different temperatures were studied for compressive strength, consistency, and setting times. It was concluded that the mechanical properties of the blended cements were mainly governed by the percentage of incorporation of the calcined clay. Blended cement composition has been formulated, with optimal results of 20% calcined clay at a temperature of 600℃. 相似文献
5.
In nature, soils are often composed of varying amounts of clay, silt and sand. Variation of the percentage of these compositions can affect the final strength of the soils when stabilised with cement. In this study, focus was placed on clayey soils with different gradation of sand impurities up to 40% in mass. An extensive study of such clayey soils treated with cement was investigated. For the results, it is noted that water:cement ratio was a major influence of strength development of cement-treated clayey soils. In contrast, the soil:cement ratio was found to have minor effects on the strength development. The presence of sand impurities has a significant reduction on the strength development of the cement-treated clayey soil mixture due to more free water available for hydration. The use of free-water:cement ratio is adopted which was shown to be capable of adjusting for such change in amount of free water and water holding capacity of the clay which is determined with Atterberg’s liquid limit tests. The effects of gradation (fine, coarse and well-graded) of the sand impurities were found to affect strength development minimally, owing to similarities in their liquid limits when mixed with clay. Ordinary Portland cement (OPC)-treated clayey soils produced a more rapid gain in strength but lower final strength at 28 days of curing as compared with Portland blast furnace cement (PBFC). This is found to be persistent for different gradation of sand impurities. A linear correlation can be established based on the log of the unconfined compressive strengths developed at different curing age, with slopes of these linear trends found to be similar for PBFC and OPC-treated clayey soil specimens. Finally, a strength prediction model comprising of these findings is developed. The parameters adopted in this model coincide with values proposed by past studies, thereby validating the robustness of the model. The practical benefits from this study offer a quality control scheme to forecast long-term performance of cement-treated clayey soils as well as optimise cement dosage in cement stabilisation to produce a more cost-effective and less environmental-invasive usage of the technology in geotechnical applications.
相似文献6.
污水浸泡对水泥土强度和电阻率特性影响的试验研究 总被引：4，自引：0，他引：4
为了揭示污水对水泥土的影响规律,并尝试采用电阻率法作为描述强度和污染特征的手段,把粉质黏土和两种水泥（普通硅酸盐水泥、矿渣硅酸盐水泥）制作的水泥土试块分别浸泡在3种液体（自来水、生活污水、造纸厂污水）中模拟环境侵蚀。首先对比分析了污水对土体液塑限的影响,其次研究了龄期、水泥类型、污水类型等对水泥土抗压强度和电阻率的影响,考察了电阻率和抗压强度的关系。结果表明：污染后土样的液限、塑限均增大,塑性指数减小;水泥土抗压强度和电阻率均随龄期增加而增长;污水均降低了水泥土的抗压强度和电阻率,但是矿渣硅酸盐水泥土的抗压强度和电阻率均高于普通硅酸盐水泥土,说明在污水环境中,矿渣水泥对水泥土有一定的抗劣化能力;在不同的龄期、水泥类型、污水类型下,水泥土电阻率均与抗压强度呈现出一致的变化规律,二者线性相关。 相似文献
7.
石灰-水泥复合土增强机制研究 总被引：3，自引：0，他引：3
利用比强度方法分析水泥土及石灰水泥土无侧限抗压强度,对石灰水泥土的增强机制进行了研究。采用内蒙古河套粉质黏土拌制水泥土及石灰水泥土试件,水泥土和石灰水泥土掺入不同量的氢氧化钙、碳酸钙和水泥,并按标准养护28 d,进行单轴抗压试验,测得水泥土及石灰水泥土的无侧限抗压强度值。研究结果表明：石灰水泥土和水泥土中存在化学胶凝和物理填充两大类作用。其中石灰水泥土中存在水化作用、硬凝作用、离子交换及团粒化作用和复合作用等4类化学增强作用;水化作用是水泥土和石灰水泥土强度增长的最主要来源;熟石灰能够抑制水化作用。 相似文献
8.
软黏土具有压缩性强、承载能力低的特点,实际工程中多用水泥作为固化剂对软黏土进行加固。云母是软黏土中较为常见的一种片状矿物,其含量和颗粒大小会影响水泥加固后的软黏土即水泥软黏土的强度。通过无侧限抗压强度试验和直接剪切试验研究云母含量及目数对水泥软黏土抗压强度及抗剪强度的影响,提出了云母含量、目数与水泥软黏土抗压强度、抗剪强度指标值之间的关系。试验中云母目数设定为10,20,40,80目共4个梯度,云母含量设定为0%、8%、16%、24%、32%共5个梯度。试验结果表明,云母含量的增加以及云母目数的减小会导致水泥软黏土无侧限抗压强度和抗剪强度的降低,且其对无侧限抗压强度的不利影响更为显著。含10目32%云母的水泥软黏土的强度减少量最大,此时无侧限抗压强度为0.33 MPa,是不含云母水泥软黏土的25.5%;黏聚力为76.5 kPa,比不含云母时减少了12.24 kPa;内摩擦角由不含云母时的23.71°降低至21.77°。云母自身的片状形态及其对水泥水解水化作用、离子交换作用的阻碍是造成水泥软黏土强度降低的主要原因。 相似文献
9.
矿渣胶凝材料固化软土的力学性状及机制 总被引：4，自引：0，他引：4
利用矿渣胶凝材料固化软土,既可利用工业废渣,又能减少水泥的用量。以矿渣胶凝材料固化黏土、砂土二种软土。发现矿渣胶凝材料加固软土的效果远好于水泥、石灰,其9 %掺量的固化土28 d的无侧限强度达到2.0 MPa以上,普遍高于15 %掺量的水泥固化土,且其28 d固化土的软化系数普遍高于90 %以上,固化黏土后CBR值远高于同掺量的石灰固化土。X衍射结构分析表明,矿渣胶凝材料水化时产生的高强难溶的矿物晶体是其固化软土效果好的主要原因。因此,矿渣胶凝材料是一种性能优异的软土加固材料。 相似文献
10.
掺砂水泥土的力学特性研究 总被引：3，自引：0，他引：3
通过室内掺砂水泥土的无侧限抗压强度试验,探讨在不同掺砂量、不同龄期条件下,其无侧限抗压强度发展规律。试验研究表明：在水泥掺量一定的条件下,掺入一定量的砂,可以明显地提高水泥土的强度。当水泥掺量为10%时,掺砂量为50%的水泥土强度达到最佳。而且根据实测的应力-应变曲线,详细地分析了掺砂水泥土的破坏形式为脆性剪切破坏,且随着掺砂量的增加,掺砂水泥土的剪切角逐渐增大。与此同时,还从不同的角度分析了掺砂水泥土无侧限抗压强度增长的原因,从而为工程应用提供了试验数据和理论依据。 相似文献
11.
12.
GS(Gypsum-Slag)土体硬化剂是一种由水泥、钢渣、矿渣和脱硫石膏及其他外加剂组成的新型土体固化材料。将GS土体硬化剂和水泥两种固化剂固化土作为研究对象,通过室内无侧限抗压强度试验和电镜扫描试验,研究固化土的应力-应变曲线以及土质、固化剂掺量、龄期对固化土力学性能的影响,观察其微观结构,进而对比分析GS土体硬化剂和水泥的特性,并进行现场试验加以验证。研究结果表明:相比水泥土,GS固化土应力-应变曲线存在明显峰值;GS固化土和水泥土的强度均随着掺量和龄期正增长,且GS固化土的长期强度更高;GS固化土和水泥土变形模量分别是其抗压强度的31.11~77.24倍和23.24~71.62倍;GS固化土现场成桩的完整性优于水泥土。相比水泥土,GS固化土具有强度增长快、后期强度高、经济效益好的特点,可较好满足地下工程和路基工程等土体加固应用需求。 相似文献
13.
使用低成本高硅铝矿物掺合料可在提升水泥土工程性能的同时降低水泥用量。通过开展系列抗压强度试验研究了水泥偏高岭土掺比、水/水泥偏高岭土比、凝胶总掺量和养护龄期对水泥复合偏高岭土稳定粉砂土抗压强度的影响规律,归纳了水泥复合偏高岭土稳定粉砂土的强度经验公式。结果表明：将水泥和偏高岭土按质量比5:1混合用于粉砂土稳定时可获得最佳强度提升,节约1/6水泥消耗,且该掺比关系不因凝胶总掺量变化而改变;水泥复合偏高岭土稳定粉砂土抗压强度随水/水泥偏高岭土比增加近似线性降低,随凝胶总掺量增加线性提升,随龄期发展而提高,其28天强度增加趋势仍未趋缓;总结归纳了四个关于强度影响因素的经验预测公式。该研究成果可为水泥偏高岭土用于复合稳定工程软弱土提供理论参考。 相似文献
14.
水泥改良土具有强度高、变形小、施工操作简单、质量控制容易和经济效益显著等优点,被广泛应用于路基填筑、基坑回填、边坡防护和地基换填。水泥土裂缝影响路基工程的正常运行,甚至可能危及铁路路基安全。因此,铁路路基设计需要对路基填土的抗拉强度有一定程度的了解,水泥改良土抗拉强度的确定具有重要意义。水泥改良土的抗裂性能是影响工程应用的重要因素,拉伸强度是衡量水泥土抗裂性能的关键指标。本文基于常规无侧限压缩仪自行设计了直接测量水泥改良土拉伸强度的单轴拉伸试验方法,系统地研究了水泥掺量（A）、龄期（t）、含水率（w）和干密度（ρd）对水泥改良土单轴拉伸强度（σt）的影响,水泥改良土的单轴拉伸强度随水泥掺量、龄期和干密度增加而增加,随含水率增加而减小,建立了水泥改良土的单轴拉伸强度与et/A(et是水泥改良土的孔隙比)之间的指数函数关系。结合水泥改良土的无侧限抗压强度和基质吸力的测试结果,建立了单轴拉伸强度与无侧限抗压强度和基质吸力之间的相关关系。 相似文献
15.
以南京内秦淮河疏浚淤泥为例,通过土工试验、XRD和X射线荧光光谱试验等方法,研究了城市河道淤泥的物理性质、矿物成分、化学成分等特性。试验结果显示:秦淮河淤泥粘粒含量低、有机质含量极高,矿物成分主要有石英和少量粘土矿物等。为了实现淤泥的资源化处理,运用水泥、石灰无机固化材料对淤泥进行固化改良试验及改性土无侧限抗压强度试验,结果表明随着水泥掺量增加,水泥固化土由塑性破坏向脆性破坏过渡,破坏应变在1.8%~2.2%,而石灰固化土均表现为脆性破坏,且破坏应变小于水泥土,为1%左右。水泥固化土28d强度为670kPa,固化效果优于石灰,但略低于处理一般软土的固化土强度。研究结果对处置城市河道淤泥有一定参考价值。 相似文献
16.
The mechanical behaviour of three cement-treated dredged materials (DM) was studied in the laboratory by isotropic compression and undrained triaxial tests. The intrinsic properties of the untreated and reconstituted soil were used as a reference framework to interpret the effect of cementation on the mechanical behaviour of the cement-treated DM. The isotropic compression line of the reconstituted soil is termed the intrinsic normal compression line (INCL). It is found that the isotropic compression lines of the cement-treated DM lie above the INCL, i.e. the void ratio of the cement-treated soil is higher than that of the reconstituted soil for a given confining pressure. The yield stress measured from the isotropic compression tests increases with increasing cement content and curing time. The pre-yield and post-yield shear responses of the cement-treated DM are different. Pre-yield soil specimens show a tendency to dilate, but post-yield soil specimens show a tendency to contract. Failure envelopes of the cement treated DM lie above that of the reconstituted DM. Linear Mohr–Coulomb failure envelopes were observed for the range of applied stress used in the study. The cohesion intercept increases with increasing cement content and curing time. The strength enhancement of the cement-treated DM is the result of the structures developed during cementation process. Based on a recently proposed soil water transfer model, the change in normalised bound water content, (Δmbw)N, is used to evaluate the combined effects of cement content and curing period on the mechanical behaviour of the cement-treated DM. It is found that there exists a threshold value of (Δmbw)N, beyond which the yield stress and cohesion intercept increases nonlinearly with increasing (Δmbw)N. The threshold value is equal to 0.37 for the three DM used in the study. 相似文献
17.
18.
Hossein Mola-Abasi Behrouz Kordtabar Afshin Kordnaeij 《Geotechnical and Geological Engineering》2016,34(5):1539-1551
It is widely known and well emphasized that the cemented sand is one of economic and environmental topics in soil stabilization. In some instances, a blend of sand, cement and other materials such as fiber, glass, nano particle and zeolite can commercially be available and effectively used in soil stabilization especially in road construction. In regard to zeolite, its influence and effectiveness on the properties of cemented sands systems has not been completely explored. Hence, in this study, based on an experimental program, it has been tried to investigate the potential of a zeolite stabilizer known as additive material to improve the properties of cemented sands. A total number of 216 unconfined compression tests were carried out on cured samples in 7, 28 and 90 days. Results show unconfined compression strength and failure properties improvements of cement sand specimens when cement replaced by zeolite at optimum proportions of 30 % after 28 days due to pozzolanic reaction. The rate of strength improvement is approximately 20–78 and 20–60 % for 28 and 90 days curing times respectively. The efficiency of using zeolite has been enhanced by increasing the cement content and porosity of the compacted mixture. The replacement of cement by natural zeolite led to an increase of the pH after 14 days. Chemical oxygen demand (COD) tests demonstrate that the materials with the zeolite mixture reveal stronger adsorptive capacity of COD in compare to cemented mixture. Scanning electron microscope images show that adding zeolite in cemented sand changes the microstructure (filling large porosity and pozzolanic reaction) that results in increasing strength. 相似文献
19.
20.
Clay soils, especially clay soils of high or very high swelling potential often present difficulties in construction operations. However, the engineering properties of these clay soils can be enhanced by the addition of cement, thereby producing an improved construction material. Higher strength loss of cement stabilized clay soils after soaking in water is attributed to water absorbing capacity of the clay fraction (e.g. montmorillonite). Kaolinite and illitic soils are largely inert and resist to water penetration. These clays generally develop satisfactory strengths resulting to low strength reduction [Croft, 1967]. The swelling clays such as bentonite soaked in water, due to environmental conditions, result to volume increase causing macro and micro-fracturing in engineering structures. These fractures accelerate water penetration and consequently cause greater strength loss [Sällfors and Öberg-Högsta, 2002]. The water intrusion during soaking creates swelling and disrupts the cement bonds. The development of internal and external force systems in soil mass, due to soaking conditions, establish the initiation of slaking. Internal force system of a stabilized clayey soil consists of the resultant stresses established by the bonding potential of a cementing agent and the swelling potential of a clay fraction. In an effort to study this influence of soaking conditions and final absorbed water content on the stabilization parameters (cement, compaction, curing time), both unconfined compressive strength and slaking (durability) tests were carried out on two different cement stabilized clayey mixtures consisted of active bentonite, kaolin and sand. 相似文献