共查询到20条相似文献，搜索用时 203 毫秒
1.
海底混输管线严重段塞流动的预测与控制 总被引：1，自引：0，他引：1
随着海洋油气田开发向深水海域发展,海底混输管线距离过长,且存在立管系统,容易形成严重段塞流动的现象日益严重.在严重段塞流工况下,管线的流动参数,如压降、段塞长度、段塞频率、持液率都随时间变化,并且表现为周期性变换的压力波动以及间歇出现的液塞.严重段塞流的不稳定性给油气田集输系统的设计及运行管理造成了巨大的困难.本文介绍了海底混输管线中严重段塞流动预测与控制的实验与理论研究进展,同时,对于节流、气举、分离等8类15种控制严重段塞的方法分别进行了评述,旨在为进一步开展海底油气混输管线严重段塞流动的研究提供借鉴,为工程实践提供参考. 相似文献
2.
海洋立管、海底管线和浮式平台系泊缆等柔性圆柱结构的流激振动会造成严重的疲劳损伤。目前,关于单根柔性圆柱流激振动的研究较多。为研究多根柔性圆柱系统的流激振动特性,开展了双柔性圆柱流激振动的模型试验。采用模态分析法将试验测量应变转化为位移。通过分析双柔性圆柱在并列、串列和交错排布方式下的响应位移、控制频率,揭示了双柔性圆柱的流激振动特性。研究结果表明:柔性圆柱并列排布时,两圆柱的相互作用使结构顺流向位移增大;柔性圆柱串列排布时,受遮蔽效应的影响,下游圆柱控制模态较低。由于柔性圆柱的多模态响应特性,"锁频"区后下游圆柱的位移并未显著增大;柔性圆柱交错排布时,下游圆柱发生"Wake-flutter",横流向和顺流向的控制频率接近,顺流向的位移显著增大。 相似文献
3.
管内流动会影响输流管的振动响应,目前关于输流弹性管涡激振动方面的研究较少。基于计算流体力学(CFD)方法,开展内外流对细长输流弹性管振动特性影响的研究。首先在不考虑内流的情况下将弹性管涡激振动数值预报结果与模型试验数据进行对比,验证了数值方法的可靠性。再者考虑内外流耦合作用情况下,对不同内流流速下细长输流弹性管振动位移时—空分布、顺流向最大平均偏移、振动轨迹、内部横向涡的形成与分布等进行了对比分析。结果发现,与外流流速相比,内流流速的增加虽然难以改变弹性管的主振模态,但对沿管体的振动强度影响显著。顺流向最大偏移处管体运动轨迹发生明显的变形和跳跃。在剪切外流和均匀内流对弹性管的联合作用下,沿管跨方向模态间能量转换频繁,伴随着间歇性出现或消失的沿弹性管传播的行波组分,这主要归因于复杂的双重流固耦合系统(外流—管体,内流—管体)。在内流以附加质量力、离心力和科氏力形式的激励下,弹性管内二次流现象明显。在振动过程中,内部横向涡沿管壁生成、脱落并逐渐散布于整个横截面。 相似文献
4.
5.
6.
大长细比柔性杆件涡激振动实验 总被引：3，自引：1，他引：2
涡激振动(vortex-induced vibration,VIV)是导致深海细长柔性立管发生疲劳破坏的重要因素。采用实验观测手段研究了长细比为1 750的柔性立管多模态涡激振动特性。实验中,通过采用拖车拖拉立管模型在水池中匀速行进来模拟均匀流作用下的涡激振动响应。利用光纤光栅传感器测量立管模型在横流向(cross-flow,CF)和顺流向(in-line,IL)的应变,进而通过模态分解的方法,获得立管模型涡激振动的位移。在此基础上,研究了CF以及IL方向的响应频率、位移标准差的平均值和最大值等随流速的变化规律,并分析了立管模型上测点的运动轨迹及其影响因素。 相似文献
7.
为研究海洋立管涡激振动响应并预测其疲劳寿命,在中国海洋大学物理海洋实验室大型风-浪-流水槽进行海洋立管涡激振动模型试验.考虑管内流体的流动,运用相似理论将实际海洋立管缩放为试验模型,施加不同流速的外流,测得立管在涡旋脱落时顺流向及横向振动的应变时程曲线,根据实测结果,采用Miner理论对立管进行疲劳寿命分析.结果表明:立管横向振动比顺流向振动强烈,大约高一个数量级;随骀着外流流速的增加,管道横向及顺流向振动明显增加,立管的疲劳寿命降低;立管中部及端部振动比较强烈,疲劳寿命较其它位置处低,容易发生疲劳破坏. 相似文献
8.
9.
深海柔性立管涡激振动问题广受关注,其中多立管涡激振动较传统单立管涡激振动更为复杂。使用基于Open FOAM自主开发的深海柔性立管流固耦合求解器viv-FOAM-SJTU,对阶梯流中串列双立管涡激振动展开研究。首先针对阶梯流中串列双立管模型试验工况开展验证计算,下游立管的位移响应以及频率响应与试验结果基本吻合;而后改变立管浸没长度,分别选取浸没长度为0.4L(工况1)、0.55L(工况2)以及0.7L(工况3)的三种工况进行数值计算,其中L为立管长度。数值结果表明:3种浸没长度下,上下游立管的横流向振动均为一阶模态,且工况2和工况3中上下游立管的横流向位移均方根均大于工况1;上下游立管的顺流向主振模态在工况2和工况3中均为二阶,而在工况1中为一阶,且下游立管在工况2和工况3中的顺流向振动均表现出明显的多模态振动特性。 相似文献
10.
11.
The vibration response of a free-hanging flexible riser induced by internal gas-liquid slug flow was studied experimentally in a small-diameter tube model based on Froude number criterion. The flow regime in a curved riser model and the response displacements of the riser were simultaneously recorded by high speed cameras. The gas superficial velocity ranges from 0.1 m/s to 0.6 m/s while the liquid superficial velocity from 0.06 m/s to 0.3 m/s. Severe slugging type 3, unstable oscillation flow and relatively stable slug flow were observed in the considered flow rates. Severe slugging type 3 characterized by premature gas penetration occurs at relatively low flow rates. Both the cycle time and slug length become shorter as the gas flow rate increases. The pressure at the riser base undergoes a longer period and larger amplitude of fluctuation as compared with the other two flow regimes. Additionally, severe slugging leads to the most vigorous in-plane vibration. However, the responses in the vertical and horizontal directions are not synchronized. The vertical vibration is dominated by the second mode while the horizontal vibration is dominated by the first mode. Similar to the vortex-induced vibration, three branches are identified as initial branch, build-up branch and descending branch for the response versus the mixture velocity of gas-liquid flow. 相似文献
12.
《中国海洋工程》2020,(3)
An experimental investigation on the disturbance effect of jet-type active vibration suppression device on vortexinduced vibration of deep-sea riser was carried out in the wave-flow combined flume. The vibration suppression device was designed in which the jet pipe was horizontally fixed to the front end of the riser. By varying three different excitation spacings and multi-stage outflow velocities, the influence law of the dominant frequency,dimensionless displacement and other dynamic response parameters was studied under different excitation spacings,and the mechanism and sensitive characteristics of the disturbance suppression were explored. The results indicate that the variation of excitation spacing makes gas curtain enter the strong disturbed flow region at different velocities and angles, and the coupling relationship between excitation spacing and reduced velocity is the key factor to enter the strong disturbed flow region to achieve the optimal disturbance suppression. In the strong disturbed flow region,the influence of gas curtain on the dominant frequency is obviously affected by the flow velocity, while the vibration displacement is stable at the same amplitude and is weakly affected by the flow velocity. Gas curtain can effectively disturb the formation of vortex shedding, destroy the strong nonlinear coupled vibration of the riser, and achieve better vibration suppression effect. In the weak disturbed flow region, the vortex length of the riser tail is prolonged,the strong nonlinear coupled vibration of the riser is gradually restored, and the vibration suppression effect of the device gradually decreases. 相似文献
13.
In order to study the effect of internal flow on vortex-induced vibration of flexible riser, the experiment on the vortex-induced vibration of flexible riser transporting fluid in the current was conducted in the physical oceanography laboratory of Ocean University of China. Considering the internal flowing fluid and external marine environment, the dynamic response of the flexible riser was measured. The corresponding numerical simulation was performed using the wake oscillatory model considering the extensibility of the riser system. Both the experiment and the numerical simulation indicated that with the increase of internal flow speed, the response amplitude increases, while the response frequency decreases. 相似文献
14.
Numerical study about vortex-induced vibration(VIV) related to a flexible riser model in consideration of internal flow progressing inside has been performed.The main objective of this work is to investigate the coupled fluid-structure interaction(FSI) taking place between tensioned riser model,external shear current and upward-progressing internal flow(from ocean bottom to surface).A CAE technology behind the current research which combines structural software with the CFD technology has been proposed.According to the result from dynamic analysis,it has been found that the existence of upward-progressing internal flow does play an important role in determining the vibration mode(/dominant frequency),vibration intensity and the magnitude of instantaneous vibration amplitude,when the velocity ratio of internal flow against external current is relatively high.As a rule,the larger the velocity of internal flow is,the more it contributes to the dynamic vibration response of the flexible riser model.In addition,multi-modal vibration phenomenon has been widely observed,for asymmetric curvature along the riser span emerges in the case of external shear current being imposed. 相似文献
15.
深海悬垂取水管的设计趋向于大直径、高内流流速,内流对取水管振动特性的影响不可忽略,分析内部流动引起的管道动态失稳行为以及评估失稳临界流速具有重要工程意义。基于小尺度模型试验,研究内流对深海悬垂取水管道振动特性的影响规律,结果表明：随着内流流速增加,取水管模型会发生动态失稳行为,表现为一种间歇性的近周期运动,该运动主要由管道一阶弯曲模态引起的不稳定性诱导。管道材料、顶端连接方式及底部配重块均影响其动态稳定性,顶端固定连接时质量比小的管道更易发生动态失稳;顶端变为铰接时,质量比大的管道失稳临界流速变小,质量比小的管道失稳临界流速变大。相比顶端边界条件,底部配重块对管道失稳临界流速影响不显著但可以减小其振动幅值。 相似文献
16.
海洋立管复模态动力特性分析 总被引：1，自引：0，他引：1
考虑阻尼的影响,研究海洋立管的动力特性。通过分析管内流体及管外海洋环境荷载的共同作用,建立海洋立管涡激振动偏微分方程,进而得到立管动力特性方程,用复模态分析法求解动力特性方程得到立管考虑阻尼的自振频率。算例计算表明:考虑阻尼的立管自振频率略小于不考虑阻尼的立管自振频率;立管的自振频率随着内流流速的增加而减小,但内流流速不大时,影响较小;管道长度对立管的自振频率影响较大。 相似文献
17.
In consideration of the effect of the internal flowing fluid and the external marine environmental condition on the vortex-induced vibration （VIV） of top tensioned riser （Till）, the differential equation is derived based on work-energy principles and the riser near wake dynamics is modeled by Facchinetti＇ s wake oscillator model. Then Galerkin＇ s finite element approximation is implemented to derive the nonlinear matrix equation of the coupled equations and file corresponding numerical programs are compiled which solve the coupled equations directly in the time domain. The comparison of the predicted results with the recent experimental results and the prediction of SHEAR7 is performed. The results show the validity of the proposed method on the prediction of VIV of deep water risers. The effect of internal flow on the dynamic characteristics and dynmnic response of the riser is analyzed and several valuable conelusions are drawn. 相似文献
18.
Dynamic Characteristics of Marine Risers Conveying Fluid 总被引：10，自引：0，他引：10
The lateral vibration differential equation for a marine riser conveying fluid is derived by useof the small deflection theory.and the effect of internal flow velocity and top tension on the natural fre-quency of the riser is studied by use of FEM.At the same time,the preliminary relationship between thenatural frequency and riser span under different internal flow velocities is obtained,the effect of riser sup-ports on the vibration frequency is computed.It is found that the natural frequency of the marine riser in-creases with the increase of top tension.however decreases with the increase of internal flow velocity.In ad-dition,the frequency decreases drastically with the increase of riser span. 相似文献
19.
In consideration of the effect of the internal flowing fluid and the external marine environmental condition on the vortex-induced vibration (VIV) of top tensioned riser (TTR), the differential equation is derived based on work-energy principles and the riser near wake dynamics is modeled by Facchinetti''s wake oscillator model.Then Galerkin''s finite element approximation is implemented to derive the nonlinear matrix equation of the coupled equations and the corresponding numerical programs are compiled which solve the coupled equations directly in the timedomain. The comparison of the predicted results with the recent experimental results and the prediction of SHEAR7is performed. The results show the validity of the proposed method on the prediction of VIV of deep water risers.The effect of internal flow on the dynamic characteristics and dynamic response of the riser is analyzed and severalvaluable conclusions are drawn. 相似文献
20.
Risers/pipes conveying fluid are a typical kind of slender structures commonly used in marine engineering. It is of great academic significance and application value for us to evaluate and understand the vibration characteristics and nonlinear responses of these risers under the combined action of internal and external fluid flows. In this paper, the nonplanar vibrations and multi-modal responses of pinned-pinned risers in shear cross flow are numerically studied. With this objective in mind, the van der Pol wake oscillators are used to simulate the dynamical behavior of the vortex shedding in the wake. Two nonlinear equations of motion of the riser are proposed to govern the lateral responses of the riser structure. The nonplanar nonlinear equations for the riser and wake are then discretized by employing Galerkin's method and solved by using a fourth-order Runge–Kutta integration algorithm. Theoretical results show that the coupled frequencies for cross-flow (CF) and in-line (IL) motions and the corresponding coupled damping ratio could be influenced by the external and/or internal fluid velocities. Based on extensive calculations, the dynamical behavior of the riser with various internal and external flow velocities are presented in the form of bifurcation diagrams, time traces, phase portraits, oscillation trajectories and response spectrum curves. It is shown that some interesting dynamical phenomena, such as ‘lock-in’ state, ‘figure-of-eight’ trajectory and quasi-periodic oscillation, could occur in such a fluid-structure interaction system. Our results also demonstrate that the shear parameter can significantly affect the dynamic responses of the riser. When the shear parameter of the cross flow is large, multi-modal quasi-periodic responses of the riser can be excited, showing some new features undetected in the system of fluid-conveying risers in uniform cross flow. 相似文献